How to Replace the Thermostat on a 2006 Toyota Camry (Coolant Drain & Refill)
Step-by-step thermostat housing removal, tools/parts list, coolant bleed tips, and torque specs for 1988, 1989, 1990, 1991
How to Replace the Thermostat on a 2006 Toyota Camry (Coolant Drain & Refill)
Step-by-step thermostat housing removal, tools/parts list, coolant bleed tips, and torque specs for 1988, 1989, 1990, 1991
🔧 Camry - Thermostat Replacement
Your Camry’s thermostat regulates engine temperature by controlling coolant flow to the radiator. If it sticks closed, the engine can overheat; if it sticks open, the heater may be weak and the engine may run cool.
Difficulty Level: Intermediate | Estimated Time: 1.5-3.0 hours
⚠️ Safety & Precautions
- ⚠️ Never open the radiator cap on a hot engine; hot coolant can spray and burn.
- ⚠️ Support the car with jack stands if you raise it; never rely on a jack alone.
- ⚠️ Coolant is toxic; keep it off skin and away from kids/pets, and dispose of it properly.
- ⚠️ Keep fingers/tools clear of belts and fans when the engine is running.
- 🔋 Battery disconnect is not required for this job.
🔧 Required Tools
You'll need the following tools for this repair:
- Safety glasses
- Nitrile gloves
- Floor jack (rated 2-ton minimum)
- Jack stands (rated 2-ton minimum)
- Wheel chocks
- Drain pan (at least 2-gallon)
- Funnel
- 10mm socket
- 3/8" ratchet
- 6" socket extension
- Torque wrench (5–30 Nm range)
- Hose clamp pliers
- Pick tool
- Plastic trim tool
- Shop rags
🔩 Required Parts
HowToo sells all the parts you need for this repair:
- Engine thermostat - Qty: 1
- Thermostat O-ring / gasket - Qty: 1
- Toyota Super Long Life Coolant (pink, premixed 50/50) - Qty: 2 gallons
- Lower radiator hose clamp - Qty: 1
📋 Before You Begin
- 🅿️ Park on level ground, set the parking brake, and chock the rear wheels.
- 🧊 Let the engine cool fully (preferably overnight) so the system is not pressurized.
- 🔥 Set the heater controls to HOT later during bleeding; this helps move coolant through the heater core.
🔨 Step-by-Step Instructions
Follow these steps in order:
Step 1: Raise the front (if needed) and remove the radiator cap
- Use wheel chocks behind the rear wheels.
- If you need more room, lift the front with a floor jack (rated 2-ton minimum) and support it with jack stands (rated 2-ton minimum).
- Slowly remove the radiator cap by hand only after the engine is fully cold.
Step 2: Drain enough coolant to get below thermostat level
- Place a drain pan (at least 2-gallon) under the radiator drain.
- Open the radiator drain and let coolant drain. Close it once the level is low enough that the lower radiator hose area won’t gush when removed.
- Save clean coolant only if very fresh.
Step 3: Access the thermostat housing (water inlet)
- Use a plastic trim tool and 10mm socket with a 3/8" ratchet as needed to loosen/remove any intake ducting or covers blocking access.
- Locate the thermostat housing where the lower radiator hose attaches to the engine.
Step 4: Remove the lower radiator hose from the thermostat housing
- Use hose clamp pliers to compress the clamp and slide it back on the hose.
- Twist the hose to break it loose, then pull it off. Use a pick tool gently if it’s stuck. (A pick tool is a small hook used to loosen seals without tearing them.)
- Catch any remaining coolant with the drain pan and wipe spills using shop rags.
Step 5: Remove the thermostat housing and thermostat
- Use a 10mm socket, 3/8" ratchet, and 6" socket extension to remove the thermostat housing bolts.
- Carefully separate the housing and remove the thermostat.
- Remove the old O-ring / gasket. Clean the mating surfaces with shop rags only.
Step 6: Install the new thermostat and O-ring/gasket
- Install the new O-ring / gasket on the new thermostat (or in the housing groove, depending on design).
- Install the thermostat into the engine/housing in the same orientation as removed.
- If your thermostat has a small “jiggle valve” (tiny loose pin/vent), position it at the top (12 o’clock) unless the part’s instructions specify otherwise.
Step 7: Reinstall the thermostat housing
- Start the housing bolts by hand to avoid cross-threading.
- Use a torque wrench (5–30 Nm range) and 10mm socket to tighten evenly: Torque to 10 Nm (89 in-lbs).
Step 8: Reinstall the lower radiator hose
- Push the hose fully onto the thermostat housing neck.
- Use hose clamp pliers to place the clamp back in its original position.
- Replace the clamp if it’s weak, rusty, or won’t hold tension.
Step 9: Refill coolant
- Use a funnel to refill with Toyota Super Long Life Coolant (pink, premixed 50/50).
- Fill the radiator, then fill the overflow reservoir to the FULL line.
- Reinstall the radiator cap snugly once the radiator is full.
Step 10: Bleed air and verify operation
- Start the engine and let it idle.
- Turn the heater to HOT and fan to medium.
- Watch the temperature gauge; it should rise to normal and stay steady.
- After warm-up and a short drive, let the engine cool completely, then recheck the reservoir level and top off using the funnel.
- Heat cycling helps purge trapped air.
✅ After Repair
- 🔍 Check for leaks around the thermostat housing and lower radiator hose with the engine running and after shutdown.
- 🌡️ Confirm the cabin heater blows hot air once warmed up.
- 🧪 Recheck coolant level the next morning (cold engine) and top off the reservoir if needed.
- 🚗 Test drive 10–15 minutes and confirm the temperature gauge stays normal.
💰 DIY vs Shop Cost
Shop Cost: $250-$450 (parts + labor)
DIY Cost: $40-$120 (parts only)
You Save: $130-$410 by doing it yourself!
Shop labor rates vary but typically run $100-$150/hour. This repair takes a shop approximately 1.5-3.0 hours.
🎯 Ready to get started?
HowToo makes it easy: same-day/2-day shipping on every part, plus all the tools and specialty tools you need! Check out the parts and tools sections below to add everything to your cart.


















