How to Replace the Serpentine Belt on a 2016 Honda Pilot (Step-by-Step Guide)
Tools, parts, belt routing tips, and torque specs for wheel-well access and safe installation for 2016, 2017, 2018, 2019, 2020, 2021, 2022
How to Replace the Serpentine Belt on a 2016 Honda Pilot (Step-by-Step Guide)
Tools, parts, belt routing tips, and torque specs for wheel-well access and safe installation for 2016, 2017, 2018, 2019, 2020, 2021, 2022
đź”§ Pilot - Serpentine Belt Replacement
The serpentine belt drives key accessories like the alternator and A/C compressor. If it’s cracked, squealing, or glazed, replacing it prevents loss of charging and overheating.
Difficulty Level: Intermediate | Estimated Time: 0.8-1.5 hours
Assumption: belt access is through right-front wheel well.
⚠️ Safety & Precautions
- 🧤 Work on a cool engine; keep hands clear of fans and pulleys.
- đź§Ż Support your Pilot with jack stands; never rely on a floor jack alone.
- 🔌 Keep keys away so no one can start it while your hands are near the belt.
- đź§· Do not put fingers between belt and pulleys while releasing the tensioner.
đź”§ Required Tools
You'll need the following tools for this repair:
- Floor jack (rated 3-ton minimum)
- Jack stands (rated 3-ton minimum)
- Wheel chocks
- 19mm socket
- 1/2" drive breaker bar
- Torque wrench (30-150 ft-lbs range)
- 10mm socket
- Ratchet (3/8" drive)
- 14mm box wrench
- Trim clip removal tool
- Flashlight
- Mechanic gloves
- Safety glasses
🔩 Required Parts
HowToo sells all the parts you need for this repair:
- Serpentine belt - Qty: 1
- Fender liner / splash shield push clips - Qty: 2-6
- Serpentine belt tensioner assembly - Qty: 1 (optional if noisy/weak)
- Idler pulley - Qty: 1 (optional if bearing is noisy)
đź“‹ Before You Begin
- Park on level ground, shift to Park, and set the parking brake.
- Chock the rear wheels with wheel chocks.
- Locate the belt routing diagram (often on the radiator support/underhood area). If it’s missing, take a clear photo of the current routing before removal.
- Understand the tensioner: the belt tensioner is a spring-loaded arm that keeps the belt tight.
🔨 Step-by-Step Instructions
Follow these steps in order:
Step 1: Lift the right-front corner
- Use a 19mm socket and 1/2" breaker bar to loosen the right-front lug nuts about 1/2 turn (do not remove yet).
- Use a floor jack (rated 3-ton minimum) to lift the right-front jacking point.
- Set the vehicle securely on jack stands (rated 3-ton minimum).
- Remove the wheel with the 19mm socket.
Step 2: Remove the splash shield/fender liner access panel
- Use a trim clip removal tool to remove push clips without breaking them.
- Use a 10mm socket and ratchet (3/8" drive) to remove any small bolts holding the access panel.
- Set clips/bolts aside in a tray so nothing gets lost.
- If reinstalling 10mm bolts: Torque to 10 Nm (7 ft-lbs).
Step 3: Relieve belt tension
- Shine a flashlight to find the belt tensioner pulley and the tensioner’s wrench point.
- Place a 14mm box wrench on the tensioner’s hex and rotate the tensioner to release tension. Move slowly; it’s spring-loaded.
- While holding the tensioner rotated, slide the belt off the easiest-to-reach pulley (often the alternator or a smooth idler).
- Carefully let the tensioner return to its resting position (do not let it snap back).
Step 4: Remove the old belt and check pulleys
- Pull the belt out through the wheel-well opening.
- Spin the idler and tensioner pulleys by hand. They should be smooth and quiet (no grinding, wobble, or rough spots).
- Look for oil or coolant on the belt path. Fluids can destroy a new belt quickly.
Step 5: Route the new belt
- Compare the new belt to the old one (length and rib count must match).
- Route the belt using the underhood routing diagram. Make sure the ribbed side sits in ribbed pulleys, and the smooth side rides on smooth pulleys.
- Leave one easy pulley for last (commonly the alternator pulley) so you have room to slip it on.
- Pro tip: Double-check every groove is seated.
Step 6: Apply tension and finish installation
- Use the 14mm box wrench to rotate the tensioner again.
- Slip the belt fully onto the last pulley.
- Slowly release the tensioner so it applies tension to the belt.
- Visually inspect: the belt must be centered on every pulley and fully in the grooves.
Step 7: Reinstall splash shield and wheel
- Reinstall the access panel using the 10mm socket and ratchet (3/8" drive).
- Reinstall push clips with the trim clip removal tool (or press by hand if they’re the push-pin style).
- Reinstall the wheel and hand-thread lug nuts.
- Lower the Pilot off the jack stands (rated 3-ton minimum) using the floor jack (rated 3-ton minimum).
- Use a torque wrench (30-150 ft-lbs range) to tighten lug nuts in a star pattern: Torque to 127 Nm (94 ft-lbs).
âś… After Repair
- Start the engine and let it idle while you watch the belt for 30-60 seconds (no wandering, no wobble, no chirping).
- Turn the A/C on and off and listen for squeal. A brief initial noise can happen, but it should not continue.
- After a short test drive, recheck belt alignment with the flashlight.
đź’° DIY vs Shop Cost
Shop Cost: $180-$350 (parts + labor)
DIY Cost: $35-$90 (parts only)
You Save: $145-$260 by doing it yourself!
Shop labor rates vary but typically run $100-$150/hour. This repair takes a shop approximately 0.8-1.2 hours.
🎯 Ready to get started?
HowToo makes it easy: same-day/2-day shipping on every part, plus all the tools and specialty tools you need! Check out the parts and tools sections below to add everything to your cart.


















