How to Replace the Fuel Cap on a 2008 Honda Accord (Fix EVAP Leak & Check Engine Light)
Step-by-step fuel cap replacement with safety tips, required tools/parts, and what to do if the CEL stays on for 2005, 2006, 2007, 2008, 2009, 2010, 2011
How to Replace the Fuel Cap on a 2008 Honda Accord (Fix EVAP Leak & Check Engine Light)
Step-by-step fuel cap replacement with safety tips, required tools/parts, and what to do if the CEL stays on for 2005, 2006, 2007, 2008, 2009, 2010, 2011
đź”§ Accord - Fuel Cap Replacement
Replacing the fuel cap on your Accord is a quick job that helps prevent fuel vapor leaks and can stop an EVAP-related check engine light caused by a worn seal or a cap that won’t click tight.
You’ll remove the old cap, inspect/clean the filler neck (the opening the cap seals against), and install a new cap until it clicks.
Difficulty Level: Beginner | Estimated Time: 0.1-0.2 hours
⚠️ Safety & Precautions
- ⚠️ Work outside or in a well-ventilated area; fuel vapors are flammable.
- ⚠️ No smoking, sparks, or open flames near the fuel door.
- ⚠️ If the engine was running, wait a few minutes before opening the cap to reduce vapor pressure.
- ⚠️ If you smell strong fuel odor after install, don’t drive—recheck the cap and sealing surface.
đź”§ Required Tools
You'll need the following tools for this repair:
- Nitrile gloves
- Safety glasses
- Clean shop towel
- Flashlight
🔩 Required Parts
HowToo sells all the parts you need for this repair:
- Fuel cap (OEM-style, tethered) - Qty: 1
đź“‹ Before You Begin
- 🅿️ Park on level ground, shut the engine off, and remove the key.
- ⛽ If you just drove the car, wait 2–3 minutes before opening the fuel door.
- đź§Ľ Have a clean shop towel ready to wipe the sealing surface.
🔨 Step-by-Step Instructions
Follow these steps in order:
Step 1: Open the fuel door
- Use your hand to open the fuel door on the left rear quarter panel.
- Use a flashlight to look for dirt or damage around the filler opening.
Step 2: Remove the old fuel cap
- Put on nitrile gloves and safety glasses.
- Turn the cap counterclockwise by hand until it releases, then remove it.
- If it hisses, pause briefly.
Step 3: Inspect and clean the sealing surface
- Use a flashlight to inspect the rubber seal on the cap and the metal/plastic lip (filler neck) where the cap seals.
- Use a clean shop towel to wipe the filler neck sealing lip clean and dry.
- If the old cap’s rubber seal is cracked, flattened, or sticky, that’s a common cause of EVAP leaks.
Step 4: Install the new fuel cap
- Install the new cap and turn it clockwise by hand.
- Tighten until you hear/feel it click (typically 1–3 clicks). This click is the cap’s built-in limiter so it seals correctly.
- If your cap has a tether (strap), make sure it’s not twisted and doesn’t prevent the cap from seating.
Step 5: Close up
- Close the fuel door firmly by hand.
- Use a clean shop towel to wipe off any fuel residue around the area if needed.
âś… After Repair
- 🔍 Start the engine and confirm there’s no strong fuel smell near the fuel door.
- 🛠️ If your check engine light was on for a loose cap/EVAP leak, it may take a few drive cycles to turn off on its own after replacing the cap.
- 📟 If the light stays on after a few days of normal driving, the EVAP system may have another leak and may need code reading.
đź’° DIY vs Shop Cost
Shop Cost: $30-$90 (parts + labor)
DIY Cost: $15-$45 (parts only)
You Save: $15-$45 by doing it yourself!
Shop labor rates vary but typically run $100-$150/hour. This repair takes a shop approximately 0.1-0.2 hours.
🎯 Ready to get started?
HowToo makes it easy: same-day/2-day shipping on every part, plus all the tools and specialty tools you need! Check out the parts and tools sections below to add everything to your cart.

















