How to Replace a Radiator Hose on a 2016 Ford F-150 (Fix Coolant Leaks & Overheating)
Step-by-step DIY guide with tools, parts, coolant spec, refill/bleed procedure, and leak-check tips
How to Replace a Radiator Hose on a 2016 Ford F-150 (Fix Coolant Leaks & Overheating)
Step-by-step DIY guide with tools, parts, coolant spec, refill/bleed procedure, and leak-check tips
🔧 F-150 - Radiator Hose Replacement
Replacing a radiator hose stops coolant leaks and prevents overheating. On your F-150, the job is mostly about safely draining a little coolant, swapping the hose, then refilling and checking for leaks.
Difficulty Level: Beginner | Estimated Time: 0.8-1.5 hours
⚠️ Safety & Precautions
- ⚠️ Never open the coolant cap on a hot engine; hot coolant can spray and burn.
- ⚠️ Support the truck with jack stands if you go underneath; never rely on a floor jack alone.
- ⚠️ Keep coolant off belts and electrical connectors; wipe spills immediately.
- ⚠️ Coolant is toxic to people and pets; catch every drop and dispose of it properly.
- ⚠️ Battery disconnect is not required for this job.
🔧 Required Tools
You'll need the following tools for this repair:
- Safety glasses
- Nitrile gloves
- Floor jack (rated 3-ton minimum)
- Jack stands (rated 3-ton minimum)
- Wheel chocks
- Drain pan (at least 10-quart)
- Funnel
- Pick tool
- Hose clamp pliers (specialty)
- Channel-lock pliers
- Flathead screwdriver
- 1/4" drive ratchet
- 8mm socket
- 10mm socket
- Shop towels
- Flashlight
🔩 Required Parts
HowToo sells all the parts you need for this repair:
- Radiator hose - Qty: 1
- Hose clamps - Qty: 2
- Engine coolant (prediluted) meeting Ford spec WSS-M97B44-D2 - Qty: 1-2 gallons
📋 Before You Begin
- 🅿️ Park on level ground, set the parking brake, and chock the rear wheels.
- 🧊 Let the engine cool completely (radiator hoses should feel cool, not warm).
- 🧼 Lay shop towels under the hose area to catch small spills.
- 🧰 If you need access from below (common for the lower hose), raise the front with a floor jack and support with jack stands.
🔨 Step-by-Step Instructions
Follow these steps in order:
Step 1: Relieve pressure safely
- Use safety glasses and nitrile gloves.
- Place a shop towel over the coolant reservoir cap.
- Slowly loosen the cap by hand to make sure there is no pressure, then remove it.
Step 2: Drain enough coolant to drop the level below the hose
- Position a drain pan (at least 10-quart) under the radiator area using a flashlight to see clearly.
- If equipped with a radiator drain (petcock), open it carefully (often hand-turn or small turns with channel-lock pliers if stuck).
- If there is no easy drain access, you can drain by loosening the lower hose clamp in a controlled way (next steps) and letting a small amount drain into the pan.
- Drain only what you need to minimize mess.
Step 3: Remove any air intake ducting blocking access (if needed)
- Use an 8mm socket with a 1/4" drive ratchet to loosen hose clamps on the intake duct.
- Use a flathead screwdriver for any push-clips or clamp screws if present.
- Lift the duct out of the way and set it aside.
Step 4: Release the hose clamps
- Use hose clamp pliers (specialty) to squeeze spring-style clamps and slide them back on the hose. (Hose clamp pliers are pliers made to squeeze and hold spring clamps open.)
- If you have worm-gear clamps instead, loosen them with a flathead screwdriver (or 8mm socket with a 1/4" drive ratchet).
Step 5: Break the hose seal and remove the hose
- Keep the drain pan underneath the connection.
- Twist the hose by hand to break it loose.
- If it is stuck, carefully work around the hose end with a pick tool to separate the rubber from the fitting.
- Pull the hose off the radiator/engine fitting and let any remaining coolant drain into the pan.
- Do not pry hard on the radiator neck; it can crack.
Step 6: Prep the fittings and compare parts
- Use shop towels to clean the radiator neck and the engine/thermostat housing neck.
- Use a flashlight to inspect for cracks, heavy corrosion, or a broken hose bead (the raised lip that helps the clamp hold).
- Match the new hose to the old hose (same bends and length).
Step 7: Install the new radiator hose and clamps
- Slide new clamps onto the hose before installing the hose.
- Push the hose fully onto each fitting until it bottoms out.
- Reposition the clamps near the end of the hose, behind the raised bead on the fitting.
- For spring clamps, use hose clamp pliers (specialty) to move them into place.
- For worm-gear clamps, tighten with a flathead screwdriver (or 8mm socket and 1/4" drive ratchet) until snug; do not over-tighten and cut the hose.
Step 8: Reinstall any removed intake parts
- Reinstall the intake duct.
- Use an 8mm socket with a 1/4" drive ratchet to tighten the intake duct clamps until snug.
Step 9: Refill coolant
- Close the radiator drain if you opened it.
- Use a funnel to refill the coolant reservoir with engine coolant meeting Ford spec WSS-M97B44-D2.
- Fill to the MAX line (or slightly below) with the engine cold.
Step 10: Bleed air and check for leaks
- Start the engine and let it idle while watching the temperature gauge.
- Set the heater to HOT and fan to medium to help circulate coolant.
- Use a flashlight to inspect both ends of the new hose for seepage.
- After the thermostat opens (upper hose gets hot), shut the engine off and let it cool.
- Top off the reservoir as needed using the funnel.
- Two heat cycles usually burp remaining air.
✅ After Repair
- 🧪 Recheck coolant level the next morning (engine cold) and top off if needed.
- 🔎 Look under the truck for drips after your first drive.
- 🌡️ Confirm normal operating temp and good heater output (no cold air at idle).
- 🧼 Rinse any spilled coolant off painted surfaces with water.
💰 DIY vs Shop Cost
Shop Cost: $180-$420 (parts + labor)
DIY Cost: $35-$120 (parts only)
You Save: $145-$300 by doing it yourself!
Shop labor rates vary but typically run $100-$150/hour. This repair takes a shop approximately 0.8-1.5 hours.
🎯 Ready to get started?
HowToo makes it easy: same-day/2-day shipping on every part, plus all the tools and specialty tools you need! Check out the parts and tools sections below to add everything to your cart.


















