2016 Ford F-150 5.0L Timing Chain Replacement Guide (No Timing Belt)
Step-by-step DIY instructions, required tools/parts, safety tips, and timing setup notes for 2015, 2016, 2017
2016 Ford F-150 5.0L Timing Chain Replacement Guide (No Timing Belt)
Step-by-step DIY instructions, required tools/parts, safety tips, and timing setup notes for 2015, 2016, 2017
🔧 F-150 - Timing Belt Replacement
Your F-150 5.0L does not have a timing belt. It uses a timing chain system (chains, guides, tensioners, and cam phasers) behind the front engine cover.
Below is the correct DIY procedure for replacing the timing chain components—this is a high-precision job because cam/crank timing must be held in the correct position.
Difficulty Level: Advanced | Estimated Time: 10-14 hours
⚠️ Safety & Precautions
- ⚠️ Disconnect the negative battery cable before any disassembly.
- ⚠️ Work only on a fully cooled engine (hot coolant/oil can burn you).
- ⚠️ Support the truck with jack stands; never rely on a floor jack.
- ⚠️ Keep fingers/tools clear of the fan and belt path during checks.
- ⚠️ Many fasteners in this area can be torque-to-yield (single-use “stretch” bolts). Replace them when required.
- ⚠️ Incorrect timing can cause severe engine damage. Use the correct Ford timing holding tools.
🔧 Required Tools
You'll need the following tools for this repair:
- Safety glasses
- Nitrile gloves
- Floor jack (rated 3-ton minimum)
- Jack stands (rated 3-ton minimum)
- Wheel chocks
- Drain pan (at least 10-quart)
- Funnel
- Trim clip removal tool
- Flat screwdriver
- Socket set (8mm-21mm)
- Deep socket set (8mm-21mm)
- Wrench set (8mm-21mm)
- Breaker bar (1/2-inch drive)
- Torque wrench (10-150 ft-lbs range)
- Torque angle gauge (specialty)
- Serpentine belt tool (specialty)
- Harmonic balancer puller kit (specialty)
- Ford 5.0L timing tool kit (specialty)
- Pry bar
- Razor scraper
- Brake cleaner spray
- Shop rags
🔩 Required Parts
HowToo sells all the parts you need for this repair:
- Timing chain kit (primary/secondary chains, guides, tensioners) - Qty: 1
- Cam phasers (recommended if noisy/worn) - Qty: 2
- Front timing cover gasket set - Qty: 1
- Valve cover gasket set - Qty: 1
- Front crankshaft seal - Qty: 1
- Crankshaft pulley bolt (one-time-use) - Qty: 1
- Engine coolant (Motorcraft-spec equivalent) - Qty: As needed
- Engine oil - Qty: As needed
- Oil filter - Qty: 1
- RTV silicone sealant (Ford-spec equivalent) - Qty: 1
📋 Before You Begin
- Park on level ground, set the parking brake, and chock the rear wheels.
- Disconnect the negative battery cable using a 10mm socket.
- Raise the front and support with jack stands.
- Place a drain pan under the radiator area; draining coolant is required.
- Bag and label bolts by component.
🔨 Step-by-Step Instructions
Follow these steps in order:
Step 1: Remove the intake tube and open up workspace
- Loosen hose clamps using an 8mm socket and remove the intake tube.
- Release wiring clips using a trim clip removal tool so harnesses aren’t pulled tight.
Step 2: Drain coolant
- Position a drain pan and drain the cooling system.
- Use a flat screwdriver if needed to open splash shield clips for access.
Step 3: Remove the serpentine belt
- Rotate the belt tensioner with a serpentine belt tool (specialty) (a long handled tool made to move spring-loaded tensioners safely).
- Remove the belt and note routing before removal.
Step 4: Remove components blocking the front cover
- Remove accessory fasteners using a socket set (10mm-15mm).
- Move components aside carefully; do not hang them by hoses or wiring.
- On reassembly: Torque to Ford specification (refer to service information) using a torque wrench.
Step 5: Remove ignition coils and valve covers
- Remove coil bolts with a 8mm socket, unplug connectors, and lift coils out.
- Remove valve cover bolts with an 8mm socket and lift covers off.
- Clean gasket surfaces with a razor scraper, then wipe with brake cleaner spray and shop rags.
- On reassembly: Torque to Ford specification (refer to service information) using a torque wrench.
Step 6: Remove the harmonic balancer (crank pulley)
- Remove the crank bolt using a breaker bar (1/2-inch drive) and correct socket.
- Remove the balancer using a harmonic balancer puller kit (specialty) (a threaded puller that draws the pulley off without prying).
- Never pry against the timing cover.
Step 7: Remove the front timing cover
- Remove cover bolts using a socket set (8mm-13mm).
- Break the seal gently with a pry bar only at cast pry points.
- Clean old RTV/gasket material with a razor scraper and brake cleaner spray.
Step 8: Set the engine to the correct timing position and lock it
- Rotate the engine by hand using a breaker bar (1/2-inch drive) and correct socket on the crank.
- Install the Ford 5.0L timing tool kit (specialty) to lock the crank and cams in place.
- Torque to Ford specification (refer to service information) for any timing tool fasteners, using a torque wrench.
Step 9: Remove tensioners, guides, and chains
- Remove tensioners and guides using the appropriate socket.
- Remove the timing chains carefully and keep track of each chain location.
- Inspect guide surfaces for missing plastic and check for obvious slack.
Step 10: Install new chains, guides, and tensioners
- Install new guides using a socket set and tighten with a torque wrench: Torque to Ford specification (refer to service information).
- Align colored chain links to the timing marks exactly (follow the chain kit/Ford diagram).
- Install new tensioners using a socket set and tighten with a torque wrench: Torque to Ford specification (refer to service information).
- Double-check marks before pulling tensioner pins.
Step 11: Install new crank seal and reseal the front cover
- Install the front crankshaft seal squarely (do not cock it).
- Apply RTV silicone sealant at the required joints/corners (where the front cover meets other sealing surfaces).
- Install the front cover and tighten evenly using a torque wrench: Torque to Ford specification (refer to service information).
Step 12: Reinstall the harmonic balancer with a new crank bolt
- Slide the balancer on straight; do not hammer it on.
- Install a new crankshaft pulley bolt.
- Tighten using a torque wrench and torque angle gauge (specialty): Torque to Ford specification (refer to service information).
Step 13: Reinstall valve covers, accessories, and serpentine belt
- Install new valve cover gaskets and reinstall covers using an 8mm socket.
- Tighten with a torque wrench: Torque to Ford specification (refer to service information).
- Reinstall accessories using a socket set and tighten with a torque wrench: Torque to Ford specification (refer to service information).
- Reinstall the belt using a serpentine belt tool (specialty).
Step 14: Refill fluids and first start
- Refill coolant using a funnel and top off engine oil; replace the oil filter if oil was drained/contaminated.
- Reconnect the battery using a 10mm socket.
- Start the engine and let it idle. If you hear loud rattling or knocking, shut it off immediately.
✅ After Repair
- Verify there are no coolant or oil leaks around the front cover and crank seal area.
- Bring the engine to operating temperature and recheck coolant level after it cools back down.
- Check for warning lights; if the check engine light comes on, scan for codes (timing correlation codes mean timing must be rechecked).
- Test drive gently, then recheck for seepage and fluid levels.
💰 DIY vs Shop Cost
Shop Cost: $2,000-$4,500 (parts + labor)
DIY Cost: $400-$1,500 (parts only)
You Save: $1,600-$3,000 by doing it yourself!
Shop labor rates vary but typically run $100-$150/hour. This repair takes a shop approximately 10-14 hours.
🎯 Ready to get started?
HowToo makes it easy: same-day/2-day shipping on every part, plus all the tools and specialty tools you need! Check out the parts and tools sections below to add everything to your cart.


















