How to Replace the Serpentine Belt on a 2016 Kia Sedona (Step-by-Step Guide)
Tools, parts list, belt routing tips, safety checks, and key torque specs for a smooth DIY install for 2015, 2016, 2017, 2018
How to Replace the Serpentine Belt on a 2016 Kia Sedona (Step-by-Step Guide)
Tools, parts list, belt routing tips, safety checks, and key torque specs for a smooth DIY install for 2015, 2016, 2017, 2018
đź”§ Sedona - Serpentine Belt Replacement
The serpentine belt drives key accessories like the alternator and A/C compressor. Replacing it restores proper grip and helps prevent squealing, charging issues, or overheating from a failed belt.
Difficulty Level: Intermediate | Estimated Time: 0.8-1.5 hours
⚠️ Safety & Precautions
- 🛑 Work on a cool engine; hot pulleys and coolant parts can burn you.
- 🛑 Keep fingers/clothing clear of the belt path and pulleys.
- 🛑 Support the van with jack stands if you lift it; never rely on a jack alone.
- 🛑 Battery disconnect is not required, but keep the key off and hands away from the radiator fans (they can turn on unexpectedly).
đź”§ Required Tools
You'll need the following tools for this repair:
- Safety glasses
- Mechanic gloves
- Wheel chocks
- Floor jack (rated 3-ton minimum)
- Jack stands (rated 3-ton minimum)
- 21mm socket
- 1/2" drive breaker bar
- 1/2" drive ratchet
- 17mm socket
- 14mm socket
- 10mm socket
- 6" extension (1/2" drive)
- Trim clip remover
- Flashlight
- Torque wrench (10-150 ft-lbs range)
- Serpentine belt tool (specialty)
🔩 Required Parts
HowToo sells all the parts you need for this repair:
- Serpentine belt - Qty: 1
- Plastic push clips (splash shield/wheel liner) - Qty: 2-6
đź“‹ Before You Begin
- đź§° Park on level ground, shift to Park, and set the parking brake.
- đź§° Chock the rear wheels using wheel chocks.
- 🧰 Locate the belt routing diagram (usually on the radiator support/underhood label). If it’s missing, take a clear photo of the current routing before removing the belt.
- 🧰 A “serpentine belt tool” is a long, slim handle that fits in tight spaces.
🔨 Step-by-Step Instructions
Follow these steps in order:
Step 1: Access the belt area
- Open the hood and use a flashlight to identify the belt, tensioner, and pulleys.
- If you have enough room from the top, continue to Step 2.
- If access is tight, use the “wheel well access” method below.
Step 2 (Wheel well access, if needed): Lift the front-right and remove the wheel
- Use a 21mm socket and 1/2" breaker bar to loosen the front-right lug nuts 1 turn (do not remove yet).
- Lift the front-right using a floor jack (rated 3-ton minimum) at the proper jacking point.
- Place jack stands (rated 3-ton minimum) and lower onto the stands.
- Remove the lug nuts with a 21mm socket and 1/2" ratchet, then remove the wheel.
Step 3 (Wheel well access, if needed): Remove the splash shield / liner section
- Remove fasteners using a 10mm socket.
- Remove plastic clips using a trim clip remover.
- Peel back/remove the liner section to expose the belt and tensioner.
Step 4: Relieve belt tension
- Install a 17mm socket on the belt tensioner hex (the spring-loaded arm).
- Use a 1/2" drive ratchet or serpentine belt tool (specialty) to rotate the tensioner to relieve tension.
- While holding the tensioner rotated, slip the belt off the easiest-to-reach smooth pulley (usually the alternator or an idler).
- Slowly release the tensioner back to its resting position. Don’t let it snap back.
Step 5: Remove the belt and inspect pulleys
- Remove the belt from the remaining pulleys by hand.
- Spin each pulley by hand and listen/feel for roughness or wobble (idler and tensioner pulleys are common wear items).
- If you see cracks, glazing (shiny surface), or missing ribs on the belt, replacement was due.
Step 6: Route the new belt
- Match the new belt to the old belt length and rib count before installing.
- Route the new belt using the underhood routing diagram (or your photo).
- Make sure the ribs sit fully inside the grooves on every ribbed pulley. Smooth pulleys ride on the belt’s smooth side.
- Leave the easiest pulley for last (the one you’ll slip on after releasing the tensioner).
Step 7: Apply tension and seat the belt
- Rotate the tensioner again using a 17mm socket with a 1/2" drive ratchet or serpentine belt tool (specialty).
- Slip the belt over the final pulley, then slowly release the tensioner.
- Double-check belt alignment on every pulley with a flashlight. One rib off will shred the belt.
Step 8: Reinstall liner/wheel (if removed)
- Reinstall the splash shield/liner fasteners using a 10mm socket.
- Reinstall the wheel and hand-start lug nuts.
- Lower the van off the jack stands using the floor jack (rated 3-ton minimum).
- Torque the lug nuts in a star pattern using a torque wrench: Torque to 108 Nm (80 ft-lbs).
Step 9 (Only if you removed tensioner/idler for repair): Torque specs
- Tensioner mounting bolts (if removed): use a 14mm socket and torque wrench, Torque to 45 Nm (33 ft-lbs).
- Idler pulley bolt (if removed): use a 14mm socket and torque wrench, Torque to 50 Nm (37 ft-lbs).
âś… After Repair
- Start the engine and let it idle for 30-60 seconds while you watch the belt track smoothly.
- Listen for chirping/squeal; if you hear it, shut off the engine and re-check that the belt is fully seated in every groove.
- Turn A/C on and headlights on to load the belt system; confirm no slipping noise.
- After a short drive, recheck belt alignment one more time.
đź’° DIY vs Shop Cost
Shop Cost: $180-$350 (parts + labor)
DIY Cost: $30-$75 (parts only)
You Save: $150-$275 by doing it yourself!
Shop labor rates vary but typically run $100-$150/hour. This repair takes a shop approximately 0.8-1.5 hours.
🎯 Ready to get started?
HowToo makes it easy: same-day/2-day shipping on every part, plus all the tools and specialty tools you need! Check out the parts and tools sections below to add everything to your cart.


















